ATD Tools ATD-3306 Manual

next previous

SAFETYWARNINGANDPRECAUTIONS

GeneralSafetyWarnings:

WARNING:Theinstructionsandwarningscontainedinthismanualshouldbereadandunderstoodbeforeusing

oroperatingthistool.Donotallowanyonetouseoroperatethistooluntiltheyhavereadthismanualandhave

developedathoroughunderstandingofhowthistoolworks.Failuretoobserveanyof

thefollowinginstructionscould

resultinseverepersonalinjurytoto oluserandbystanders,orcausedamagetothetoolandproperty.Keepthismanual

forfuturereference.

Note:Thewarningsandcautionsdiscussedinthisinstructionmanualcanno tcoverallpossibleconditionsand

situationsthatmayoccur.Itmustbeunderstoodbytheoperatorthatcommonsenseandcautionarefactorswhich

cannotbebuiltintothisproduct,butmustbesuppliedbytheoperator.

WARNING:Usesafetyequipment.Userandbystandersshouldusesafetygogglesorsafetyglasseswithsideshields

whichcomplywithcurrentnationalstandards,orwhenneeded,afaceshield.UseanANSIapprov eddustmaskorrespirator

whenworkingaroundmetal,wood,andchemicaldustsand mists. Thisappliestoall persons

in the workarea.Alsouse

non‐skidsafetyshoes,hardhat,gloves,dustcollectionsystems,andhearingprotectionwhenappropriate.

WARNING:Keepbystandersandchildrenoutoftheworkareawhileoperatingthistool.

WARNING:Alwayskeepyourworkareaclean,uncluttered,andwelllit.Clutteredordarkareasinviteaccidentsand

injuries.DONOTworkonfloorsurfacesthatareslippery.

WARNING:Donotoperatethistoolifyouaretiredorundertheinfluenceofalcohol,drugs,ormedicationsthatcould

aff ectyourabilitytousethetoolproperly.

WARNING:Dresspr operly.Donotwearlooseclothingorjeweleryastheycanbecaughtinmovingparts.Wear

restrictivehaircoveringtocontainlonghair.

WARNING:Donotreachoveroracrossrunningmachines.Keepproperfootingandbalanceatalltimes.Non‐skid

footwearisrecommendedwhenworking.

OPERATING INSTRUCTIONS:

To Test For Leaks In Original Radiator Cap

1. Refertothevehicle’sservicemanualforanyspecificradiatorcappressuretestinginstructions.

2. Loosenthevehicle’sradiatorcapslowlytorelieveanyexcesspressurebeforeremovingthecapcompletely.NEVEROPEN

THESYSTEMWHILEHOT,asthismaycausepersonalinjury.

3.Choosethecorrectradiator

capconnector(5Aor5B)andcorrectsteelradiatorcap(#02,#03,or#04)forthecorrect

vehiclebeingtestedfromthetestkit.Fastentheoriginalradiatorcaptotheradiatorcapconnector(5Aor5B)andthen

fastenthesteelradiatorcap(#02,#03,or#04)fromthe

testkittotheotherendoftheradiatorcapconnector(5Aor5B).

4.Removethehandpumpassembly(#1)fromthetestkitandfastenthequickcouplerattheendofthehosetotheradiator

cap(#02,#03,or#04)securely.Operatethehandpumpuntilreachingthe

pressurerecommendedbythevehicle

manufacturer.‐DONOTOVERPRESSURIZETHERADIATORCAP.Idealreadingsshouldrangebetween15‐20PSI

(1.03‐1.37BAR).

